Bridge Special Provisions

General

The Bridge Special Provisions, published by the State Bridge Office, may be used by MoDOT's internal staff, as well as consultants, and may be used by other department of transportation agencies as a reference. The Bridge Special Provisions are to be used as an aid to assist in developing Job Specific Special Provisions for statewide bridge related construction projects.

The exclusive purpose of the Bridge Special Provisions is to provide information as a convenience to those who access it. It is the users responsibility to verify the information presented is applicable to their particular project or situation.

Section	Title	Date
000	Miscellaneous
	Formatting Instructions for Job Special Provisions	08/29/05
	Job Special Provisions Table of Contents	02/09/12

104	Scope of Work
	Construction Requirements	07/08/11
	Gauging Station Removal	10/27/10
	Alternate Structures	04/04/08
	Design of Pre-Engineered Structures for Grade Separations	02/29/08
	Design of Pre-Engineered Structures for Stream Crossings	02/29/08

105	Control of Work
	Cooperation Between Contractors	08/29/05

106	Control of Material
	Metric Substitution - Pipe Piles, Column Forms & Reinforcing Steel	08/29/05

216	Removals for Bridge Structures
	Match Marking Removal of Bridges	08/29/05
	Major Bridge Removal Specials	08/29/05
	Removal of Cathodic Protection System	08/29/05

501	Concrete
	Rapid Set Concrete Patching Material - Horizontal Repair JSP-02-01A (See MoDOT internet Job Special Provisions Site)	02/01/11
	Rapid Set Concrete Patching Material - Overhead and Vertical Repairs JSP-02-01 (See MoDOT internet Job Special Provisions Site)	02/01/11

505	Bridge Deck Concrete Wearing Surface
	Surface Sealing Low Slump Concrete	08/29/05

622	Pavement and Bridge Surface Removal and Texturing
	Slurry and Residue Produced During Surface Treatment of PCCP and Bridge Decks JSP-06-05 (See MoDOT internet Job Special Provisions Site)	04/28/06

702	Load Bearing Pile
	Static Load Testing	08/29/05
	Dynamic Pile Testing	10/26/10
	Galvanized Structural Steel Pile and Bracing	11/14/11

703	Concrete Masonry Construction
	Clearance Gauge	08/29/05
	Cold Weather Concreting	08/29/05
	Form Liners	03/19/06
	Surface Sealing Concrete	08/29/05

704	Concrete Masonry Repair
	Deck Girder End Repair	08/29/05
	Total Surface Hydro Demolition	11/02/11
	Epoxy Pressure Injecting	08/29/05
	Half Concrete Filled Steel Grid Deck Repairs	08/29/05
	Clean and Epoxy Seal	10/25/05
	Concrete Wearing Surf ice Repair	09/16/09
	Hydro Surface Profiling	12/23/10

705	Prestressed Concrete Members for Bridges
	Post-Tensioned Concrete I-Girders	08/29/05

707	Conduit System on Structure
	Cathodic Protection System	08/29/05
	Electrical Grounds	08/29/05

711	Protective Coatings for Exposed Concrete Surfaces
	Dampproofing	08/29/05
	Waterproofing	08/29/05
	Waterproofing Membrane	08/19/09
	Protective Surface Treatment for Concrete- Penetrating Sealers JSP -07-08 (See MoDOT internet Job Special Provisions Site)	12/01/07
	Waterproofing Prestressed Slab Beam Ends	10/30/08

712	Structural Steel Construction
	Cleaning, Lubricating and Coating Existing Bearings	08/29/05
	Coating Galvanized Slab Drains	10/25/05
	Drainage System	10/21/10
	Earthquake Restrainers	08/29/05
	Existing Diaphragm Connection to Flange	04/09/10
	Grouting Short Column Jackets	08/29/05
	Non-Destructive Testing	05/14/07
	Pressure Grouting Long Column Jackets	08/29/05
	Rivet Removal and Replacement	08/29/05
	Slab Drain with Grate	08/29/05
	Steel Grid Floor (Half Concrete Filled)	08/29/05
	Strengthening Existing Stringers	01/14/11
	Structural Steel Protective Coating Requirements (used w/ no plans)	01/11/11
	Structural Steel Requirements	08/29/05
	Chloride Remediation Process	04/01/09
	Hinge Modification	03/08/11

716	Neoprene Bearings
	POT Bearings	10/21/10

717	Neoprene & Silicone Joint Systems
	Modular Expansion Joint System	8/29/05
	Preformed Silicone or EPDM Expansion Joint Seal	02/03/11

718	Temporary Bridge
	Superstructure Furnished by the Contractor	08/29/05

720	MSE Wall Design
	MSE Wall Design Clarification	8/30/11

725	Metal Pipe and Pipe-Arch Culverts
	Corrugated Metal Pipe Pile Spacers	03/02/11

727	Structural Plate Pipe and Pipe-Arch Culverts
	Pre-Engineered Structural Plate Structures	01/03/08

733	Precast Concrete Box Culverts
	Pre-Engineered Precast Concrete Structures	10/31/07

901	Highway Lighting
	Navigation Lighting System	08/29/05

1081	Coating of Structural Steel
	Overcoating of Structural Steel (System G)	08/29/05

For technicial support, questions or errors please contact bppl@modot.mo.gov.

Our mission is to provide a world-class transportation experience that delights our customers and promotes a prosperous Missouri.